服务热线:15953195999
产品中心
您所在的位置:首页-新闻中心-新闻动态济南二手叉车使用注意事项

济南二手叉车使用注意事项

来源:https://www.jnhgjx.net/ 日期:2024-02-13 发布人:

1,行车前,司机应察看和清理现场、通道,使其适于叉车作业和行驶;起步时,应先合上应急开关、打开电锁,然后扳好方向开关的位置,鸣号,再缓慢起步并逐渐加速,禁止快速踏下调速踏板起步,以防启动电流过大而烧坏电机;

Before driving, the driver should first inspect and clean the site and passages to make them suitable for forklift operation and driving; When starting, the emergency switch should be turned on, the electric lock should be turned on, the direction switch should be turned on, the horn should sound, and then slowly start and gradually accelerate. It is prohibited to quickly press the speed control pedal to start, in order to prevent the motor from being burned out due to excessive starting current;

2,行车时,应逐渐加速,不允许长时间低速行驶;会、让车时,应空车让重车;

20221114083702342.jpg

2. When driving, gradually accelerate and do not allow prolonged low-speed driving; When meeting or giving way to vehicles, empty vehicles should give way to heavy vehicles;

3,行驶中严禁扳动方向开关,只有在车停稳后。才能扳动方向开关换向。应尽量避免急刹车,如遇紧急情况,应迅速拉下闸刀开关,踩下制动踏板,即刻停车;

3. It is strictly prohibited to turn the direction switch while driving, only after the vehicle has come to a steady stop. Only by pulling the direction switch can the direction switch be reversed. Try to avoid sudden braking. In case of emergency, quickly pull down the knife switch, step on the brake pedal, and stop immediately;

4,起步、转弯时要鸣喇叭,转弯、下坡、路面不平或通过窄通道时,要减速慢行,注意;

4. When starting or turning, honk the horn. When turning, downhill, uneven road surface, or passing through narrow passages, slow down and pay attention to safety;

5,在道路上行驶时,要靠右侧通行,叉车货又离地应在100~200mm左右,门架在后倾位置;两台车同向行驶时,前后应保持2m以上距离;

5. When driving on the road, it is necessary to rely on the right side for traffic, and the forklift cargo should be about 100-200mm off the ground, with the gantry in a backward leaning position; When two cars are driving in the same direction, a distance of at least 2 meters should be maintained between the front and back;

多台叉车在站台上行驶时,前后间距应在5m以上,在较窄站台上同向时应严禁并行,且距离站台边缘0.3m以上;

When multiple forklifts are traveling on the platform, the distance between the front and back should be at least 5m. When traveling in the same direction on narrow platforms, parallel operation should be strictly prohibited, and the distance from the edge of the platform should be at least 0.3m;

6,叉车牵引拖车时,禁止连续曲线行驶,以免大电流放电和影响;无论满载、空载、上坡、下坡等,严禁倒车行驶;转弯时,应减速慢行,以免货物散落,同时要注意内轮差,以防拖车刮碰内侧或驶出路外;

6. When towing a trailer with a forklift, continuous curved driving is prohibited to avoid high current discharge and safety impact; No matter when fully loaded, unloaded, uphill, downhill, etc., reverse driving is strictly prohibited; When turning, slow down and avoid the scattering of goods. At the same time, pay attention to the inner wheel difference to prevent the trailer from scratching the inside or driving out of the road;

一般情况下,电瓶叉车行走电机和油泵电机禁止同时工作,以延长蓄电池的使用寿命;

In general, the walking motor and oil pump motor of an electric forklift are prohibited from working simultaneously to extend the service life of the battery;

7,当工作电压低于本车低极限电压时,应停止工作,及时进行充电;

7. When the working voltage is lower than the low limit voltage of the vehicle, the operation should be stopped and charging should be carried out in a timely manner;

行车中如发现有异常现象,应立即停车检查,并及时排除故障;禁止货叉载人及拖车载人;严禁带故障行驶。

If any abnormal phenomena are found during driving, the vehicle should be stopped immediately for inspection and the fault should be promptly eliminated; Forklifts and trailers are prohibited from carrying people; Driving with faults is strictly prohibited.

济南韩工机械设备有限公司
地址:山东省济南市章丘区龙山街道济青路龙山段南侧1幢   电话:15953195999
网站:https://www.jnhgjx.net/   备案号:鲁ICP备14018186号-1  

鲁公网安备 37011202000702号

【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】