全国服务热线:15953195999
产品中心
您所在的位置:首页-新闻中心-常见问题-电动叉车出现异味怎么排除?

电动叉车出现异味怎么排除?

来源:http://www.jnhgjx.net/ 日期:2020-04-07 发布人:admin

  叉车电池臭;这种情况通常是由电解液泄漏或损耗引起的,因为电池需要电解液来完成电能的储存和转换,但当电解液泄漏时就会产生刺痒的气味;同时,如果电解液消耗过多或损耗过大,叉车充电机就会强制电池充电,这时电池就会过热,发出白烟,气味就更难闻了。当发现这些问题时,应补充电解质和电池充电。

  Forklift batteries stink, which is usually caused by electrolyte leakage or loss, because batteries need electrolyte to complete the storage and conversion of electric energy, but when electrolyte leaks, it will produce a tickling smell; At the same time, if the electrolyte consumption is too much or too much, the forklift charger will force the battery to charge, then the battery will overheat, emit white smoke, and the smell will be even worse. When these problems are found, electrolyte and battery charging should be supplemented.
  电动叉车发现了塑料糊的味道,因为这种情况大多是由电线过热引起的,因为电线的塑料护套比较薄,所以气味不是很大。但当电线短路时,多伴有局部冒烟或发热现象,时间长,容易引起燃烧、起火。一旦发现导线过热的现象,必须立即停止查找原因,虽然导线烧损的气味不大,但危险指数很高。一般情况下,夏季电线温度过高的现象会比较多,如果不及时发现,很容易造成整个电路损坏,发动机气缸,甚至车辆自燃现象。
  The smell of plastic paste is found in electric forklift because it is mostly caused by overheated wires. Because the plastic sheath of wires is thin, the smell is not very strong. However, when the wire is short circuited, it is often accompanied by local smoke or heating phenomenon, which is easy to cause combustion and fire for a long time. Once it is found that the wire is overheated, it is necessary to stop looking for the cause immediately. Although the smell of wire burning is not big, the risk index is very high. In general, the phenomenon of high wire temperature in summer will be more, if not found in time, it is easy to cause the whole circuit damage, engine cylinder, and even vehicle spontaneous combustion.
济南叉车租赁
  电动叉车发现橡胶粘贴:这气味是最容易识别,这气味的发生首先要检查皮带,刹车片和轮胎、橡胶制品在这些部分是否松动和滑或过热,如果确定制动器的气味或轮胎,应该立即停止火,如热开车前。
  Rubber sticking found in electric forklift: this smell is the easiest to identify. First, check whether the belt, brake pad and tire, rubber products are loose, slippery or overheated in these parts. If the smell of brake or tire is determined, stop the fire immediately, such as before hot driving.
  电动叉车发现有强烈的糊糊烧焦味:在驾驶过程中如果闻到非金属材料的烧焦味,这种特殊的气味一般是由离合器摩擦片烧焦或过热引起的。还有一股烧焦的味道,因为离合器片是由橡胶和石棉等材料组合而成。如果离合器工作正常,挡挡或启动没有明显的困难,而且气味来自汽车的后部,检查后刹车系统是否过热。一些粗心大意的车主强行打开手刹,这可能会导致后刹车片锁定和烧焦的味道。
  Electric forklift truck has a strong burning smell: if you smell burning smell of non-metallic materials during driving, this special smell is generally caused by burning or overheating of clutch friction plate. There is also a burning smell, because the clutch plate is made of rubber, asbestos and other materials. If the clutch works normally, there is no obvious difficulty in shifting or starting, and the smell comes from the rear of the car, check whether the rear brake system is overheated. Some careless car owners forcibly turn on the handbrake, which may lead to the smell of rear brake pad locking and burning.

济南韩工机械设备有限公司
地址:山东省济南市章丘区龙山街道办事处东3公里路北韩工叉车济南4S店   电话:15953195999
网站:http://www.jnhgjx.net/   备案号:鲁ICP备14018186号-1  技术支持:济南诺商

 

【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】